Exact make, model and year evidence from official US sources. Recall campaigns, ODI investigations, complaint allegations and EPA estimates remain separate.
A campaign may cover only certain production dates, plants or equipment. A zero result here is not safety clearance. Use NHTSA’s official VIN tool for the individual vehicle.
Exact model-level NHTSA results for 2005 HONDA Odyssey. Campaign records are official safety actions; applicability to a particular car still requires its VIN.
Delphi Automotive Systems, LLC (Delphi) is recalling certain replacement fuel pump modules, part number FG1155-11B1, sold for use in 2005-2010 Honda Odyssey vehicles. The affected fuel pump may send an incorrect fuel reading to the fuel gauge possibly causing the vehicle to run out of fuel. The fuel gauge will always read 3/4 full to full regardless of the actual level.
Consequence
A vehicle that runs out of fuel and stalls has an increased risk of a crash.
Remedy
Delphi has begun notifying dealers and distributors, and will replace the fuel pump modules, free of charge. Owners may contact Delphi customer service at 1-877-411-8770. Delphi's number for this recall is GL14-004.
American Honda Motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda Odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover may deteriorate allowing fuel to leak out.
Consequence
A fuel leak increases the risk of a fire.
Remedy
Parts to permanently repair the affected vehicles are not currently available. Honda will notify owners with an interim letter during May 2014. A second notice was mailed to owners October 6, 2014 when the remedy became available. Any vehicles that are currently leaking from the fuel pump cover will get a replacement, original cover. All vehicles, including those receiving the interim repair, will get an improved cover when they are available. Owners may contact Honda at 1-800-999-1009. The recall numbers associated with this campaign are JD9 (inspection and/or preliminary part replacement) and JE0 (final parts replacement).
03
NHTSA Recalls · US · received 2010-10-22
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2007 ODYSSEY AND ACURA RL VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS A LUBRICANT FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Consequence
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER SEAL FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2010. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
HONDA IS RECALLING CERTAIN MODEL YEAR 2005 ODYSSEY TOURING VEHICLES EQUIPPED WITH POWER OPERATED REAR LIFTGATE. THE POWER LIFTGATE GAS STRUTS MAY DETERIORATE UNEXPECTEDLY EARLY. STRUTS THAT HAVE WORN OUT PREMATURELY MAY FAIL TO HOLD THE POWER LIFTGATE IN THE FULLY OPEN POSITION, CAUSING THE POWER LIFTGATE TO CLOSE UNEXPECTEDLY.
Consequence
INJURY MAY RESULT FROM A POWER LIFTGATE CLOSING UNEXPECTEDLY WHEN A PERSON IS WITHIN THE CLOSING PATH OF THE LIFTGATE.
Remedy
DEALERS WILL INSPECT THE GAS LIFTGATE STRUTS AND REPLACE IF WITHIN THE RECALL POPULATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE CAMPAIGN BEGAN ON MARCH 26, 2010. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
ON CERTAIN MINIVANS AND SPORT UTILITY VEHICLES, THE STEERING COLUMN MAY BE INCORRECTLY ASSEMBLED, WHICH COULD RESULT IN A LOSS OF STEERING CONTROL.
Consequence
LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.
Remedy
OWNERS WERE NOTIFIED BY TELEPHONE ON JANUARY 25, 2005, AND ARRANGEMENTS WERE MADE TO HAVE THEIR VEHICLES TOWED TO THEIR DEALERS AND HAVE THE REPAIRS PERFORMED. THE RECALL BEGAN ON JANUARY 25, 2005.
06
NHTSA Recalls · US · received 2005-04-05
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
Consequence
IF THE FUEL PUMP LOSES POWER WHILE DRIVING THE ENGINE COULD STALL WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL REPLACE THE ENTIRE FUSE BOX FREE OF CHARGE. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT HONDA AT 800-999-1009 OR ACURA AT 1-800-382-2238.
THE FRONTAL AIR BAG SYSTEM HAS TWO EXTERNAL IMPACT SENSORS. ON CERTAIN MINI VANS,SOME SENSORS WERE INSUFFICIENTLY SEALED DURING MANUFACTURING. IF WATER ENTERS A SENSOR, CORROSION CAN OCCUR. CORRODED SENSORS COULD SHORT CIRCUIT INTERNALLY. IF SENSORS FAIL, THE SRS WARNING LAMP ON THE INSTRUMENT PANEL WILL TURN ON AND REMAIN ILLUMINATED.
Consequence
FRONT IMPACT SENSOR FAILURE COULD CAUSE A DELAY IN, OR LOSS OF, FRONTAL AIR BAG DEPLOYMENT, WHICH CAN INCREASE THE RISK OF INJURY IN A FRONTAL CRASH.
Remedy
DEALERS WILL REPLACE THE FRONT IMPACT SENSORS. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
ON CERTAIN VEHICLES, A COIL WIRE INSIDE THE FUEL PUMP RELAY MAY BREAK, CAUSING THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
Consequence
IF THE FUEL PUMP LOSES POWER WHILE DRIVING, THE ENGINE COULD STALL WITHOUT WARNING, AND A CRASH COULD OCCUR.
Remedy
DEALERS WILL INSPECT AND REPLACE THE FUEL PUMP RELAY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 2, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
ON CERTAIN MINIVANS, THE ANTI-LOCK BRAKE SYSTEM (ABS) USES A SENSOR ON EACH WHEEL TO DETECT WHEEL SPEED. SOME SENSORS ON THE REAR WHEELS WERE INSTALLED INCORRECTLY, WHICH MEANS THE SENSOR MAY REPORT THE WRONG WHEEL SPEED TO THE ABS CONTROL UNIT.
Consequence
THE DRIVER COULD EXPERIENCE A LOSS OF BRAKE FORCE AND A CRASH COULD OCCUR.
Remedy
DEALERS WILL INSPECT THE REAR WHEEL SPEED SENSORS. IF AN INCORRECT GAP IS DETECTED, THE SENSOR WILL BE REMOVED AND THE KNUCKLE CHECKED FOR CROSS THREADING DAMAGE. IF DAMAGE IS FOUND, THE KNUCKLE WILL BE REPLACED. IF NO DAMAGE IS FOUND, THE SENSOR WILL BE REINSTALLED CORRECTLY. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.
02 · Owner allegations
829 NHTSA complaints
Counts are not adjusted for sales, vehicle age, mileage, publicity or reporting behavior. They are allegations, not defect findings or a reliability score.
Crash mentions
19
Fire mentions
9
Injuries reported
32
Most-reported component labels
STRUCTURE138
POWER TRAIN106
STEERING99
AIR BAGS90
ENGINE AND ENGINE COOLING87
SERVICE BRAKES77
Complaints across nearby Honda Odyssey model years
Totals for the same nameplate, scaled against its highest year here. They are not adjusted for how many were sold, how old they are, how far they are driven, or how much publicity a fault received — an older or better-selling year will usually carry more reports. This shows where the reporting sits, not which year is better.
An investigation means ODI reviewed a possible safety issue for this exact model-year identity. Opening one is not a defect finding; closing one does not by itself clear a vehicle.
STRUCTURE:BODY:HATCHBACK/LIFTGATE · No associated recall campaign number was published in this investigation row.
04 · EPA configurations
Fuel economy & specifications
FuelEconomy.gov records are summarized as ranges where this model name has multiple engines, drivetrains or trims.
EPA configurations
2
Combined economy
19–20 mpg/MPGe
City / highway
17 / 23–26 mpg/MPGe
Engine displacement
3.5 L
Cylinders
6
Fuel type
Regular
Drive
Front-Wheel Drive
Vehicle class
Minivan - 2WD
Annual fuel-cost estimate
$3250–3400
05 · Evidence strength
Exact identity. Explicit limits.
No opaque score. Evidence strength is expressed through source availability, exact match method, jurisdiction and honest empty states.
exact match
Recall campaigns
9 exact US model-year records in this bounded view.
exact match
Complaints
829 exact US model-year allegations; narratives and VIN fragments are omitted.
exact match
ODI investigations
3 exact US model-year action numbers in the approved import snapshot.
canonical only
Model aliases
Only the exact NHTSA vPIC model name is published; unverified aliases are not merged.
not published
Manufacturer ownership
No rights-reviewed official ownership record is joined to this exact model-year.
PUBLIC EVIDENCE PASSPORT
Identity, freshness and provenance.
The canonical URL is this file’s permanent public identifier. Source IDs and timestamps show exactly what was matched and when; they do not turn the evidence into a verdict.
Only NHTSA vPIC, NHTSA ODI complaints and investigations, NHTSA recalls and FuelEconomy.gov contribute to this vehicle claim. CPSC equipment notices are searched separately and never joined to vehicle fitment. UK MOT, Canadian, New Zealand and European records are not merged into this US claim.
06 · Research paths
Diagnose first. Confirm fitment.
These are transparent searches, not diagnoses or endorsed parts. Recall remedies come before purchases; exact part fitment requires VIN, trim, powertrain, production date and OE number.
138 complaint labels
STRUCTURE
Check recalls and diagnostic information before replacing anything.
Awin US and R2 affiliate inventory are not published until a US programme, merchant and exact-fitment projection are approved. No offer currently has both merchant approval and exact vehicle fitment, so commercial links never count as evidence.