Exact make, model and year evidence from official US sources. Recall campaigns, ODI investigations, complaint allegations and EPA estimates remain separate.
A campaign may cover only certain production dates, plants or equipment. A zero result here is not safety clearance. Use NHTSA’s official VIN tool for the individual vehicle.
Exact model-level NHTSA results for 2009 VOLKSWAGEN Routan. Campaign records are official safety actions; applicability to a particular car still requires its VIN.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring.
Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence
If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy
Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence
Failure of the rear axle may increase the risk of a crash.
Remedy
Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence
If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy
VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence
If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy
Volkswagen will notify owners, and dealers will modify the ignition switch, free of charge. Owners may contact Volkswagen customer service at 1- 800-822-8987. An interim notice was mailed to owners on August 29, 2014. Volkswagen's number for this recall is 28G1/U8. Note: This campaign is an expansion of NHTSA Recall No. 11V-151.
VOLKSWAGEN IS RECALLING 18,500 MY 2009 ROUTAN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE OWNER'S MANUAL WAS PRINTED WITHOUT THE FMVSS NO. 208 REQUIRED INFORMATION EXPLAINING THAT NO OBJECTS SHOULD BE PLACED OVER THE OR NEAR THE AIR BAG ON THE INSTRUMENT PANEL.
Consequence
ANY SUCH OBJECTS COULD CAUSE INJURY TO THE VEHICLE'S OCCUPANTS IN THE EVENT OF A CRASH SEVERE ENOUGH TO CAUSE THE AIR BAG TO INFLATE.
Remedy
DEALERS WILL SEND AN OWNER'S MANUAL INSERT CONTAINING THE REQUIRED AIR BAG INFORMATION FOR OWNER INSTALLATION OR DEALERS WILL INSTALL IN THE EVENT THE OWNER PREFERS ASSISTANCE FROM THE DEALER. THE RECALL BEGAN ON JULY 31, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.
Consequence
THIS COULD RESULT IN AN OVERHEATED LATCH AND A FIRE WITHIN THE REAR SLIDING DOOR COULD OCCUR.
Remedy
VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
02 · Owner allegations
294 NHTSA complaints
Counts are not adjusted for sales, vehicle age, mileage, publicity or reporting behavior. They are allegations, not defect findings or a reliability score.
Crash mentions
6
Fire mentions
3
Injuries reported
12
Most-reported component labels
ELECTRICAL SYSTEM151
ENGINE78
SERVICE BRAKES56
STEERING34
POWER TRAIN20
STRUCTURE18
Complaints across nearby Volkswagen Routan model years
Totals for the same nameplate, scaled against its highest year here. They are not adjusted for how many were sold, how old they are, how far they are driven, or how much publicity a fault received — an older or better-selling year will usually carry more reports. This shows where the reporting sits, not which year is better.
An investigation means ODI reviewed a possible safety issue for this exact model-year identity. Opening one is not a defect finding; closing one does not by itself clear a vehicle.
VERIFIED EMPTY IMPORT SNAPSHOT
No exact NHTSA ODI investigation row was matched.
The checked bulk snapshot returned zero investigation action numbers for 2009 VOLKSWAGEN Routan. That is source coverage, not proof that no issue exists or will be investigated later.
04 · EPA configurations
Fuel economy & specifications
FuelEconomy.gov records are summarized as ranges where this model name has multiple engines, drivetrains or trims.
EPA configurations
2
Combined economy
18–20 mpg/MPGe
City / highway
16–17 / 23–25 mpg/MPGe
Engine displacement
3.8–4 L
Cylinders
6
Fuel type
Regular
Drive
Front-Wheel Drive
Vehicle class
Minivan - 2WD
Annual fuel-cost estimate
$3250–3600
05 · Evidence strength
Exact identity. Explicit limits.
No opaque score. Evidence strength is expressed through source availability, exact match method, jurisdiction and honest empty states.
exact match
Recall campaigns
6 exact US model-year records in this bounded view.
exact match
Complaints
294 exact US model-year allegations; narratives and VIN fragments are omitted.
verified empty
ODI investigations
0 exact US model-year action numbers in the approved import snapshot.
canonical only
Model aliases
Only the exact NHTSA vPIC model name is published; unverified aliases are not merged.
not published
Manufacturer ownership
No rights-reviewed official ownership record is joined to this exact model-year.
PUBLIC EVIDENCE PASSPORT
Identity, freshness and provenance.
The canonical URL is this file’s permanent public identifier. Source IDs and timestamps show exactly what was matched and when; they do not turn the evidence into a verdict.
Only NHTSA vPIC, NHTSA ODI complaints and investigations, NHTSA recalls and FuelEconomy.gov contribute to this vehicle claim. CPSC equipment notices are searched separately and never joined to vehicle fitment. UK MOT, Canadian, New Zealand and European records are not merged into this US claim.
06 · Research paths
Diagnose first. Confirm fitment.
These are transparent searches, not diagnoses or endorsed parts. Recall remedies come before purchases; exact part fitment requires VIN, trim, powertrain, production date and OE number.
151 complaint labels
ELECTRICAL SYSTEM
Check recalls and diagnostic information before replacing anything.
Awin US and R2 affiliate inventory are not published until a US programme, merchant and exact-fitment projection are approved. No offer currently has both merchant approval and exact vehicle fitment, so commercial links never count as evidence.